good luk lee :thumbs:

[Edited on 31-05-2009 by fillmecca]

quote:

---

Originally posted by Richardhhha
the egr will come up as faulty when you run a paper clip test they are common to go on the 14 and 16xe engines, you will most probably find that its a air leak, or in fact the MAP sensor Black box on the bulk head with a green plug and a pipe comming out of it. also the pipes tend to split on these so check them for perrishing, and good tip spray some brake cleaner or wd40 round the joints of the top half of the inlet manifold as this will show up any leaks you may have

---

yeah ano its shit lol yeah hopefully soon see a guy from egremont off anouther forum

quote:

---

Originally posted by SRI-LEE
im going in to have anouther bash 2moz like its at work and there gay and dont let non workers in so gotta do it all on my own which is gay! cheers anyway though mate :) hopefully il get it sorted tomorrow! :)

---

the egr will come up as faulty when you run a paper clip test they are common to go on the 14 and 16xe engines, you will most probably find that its a air leak, or in fact the MAP sensor Black box on the bulk head with a green plug and a pipe comming out of it. also the pipes tend to split on these so check them for perrishing, and good tip spray some brake cleaner or wd40 round the joints of the top half of the inlet manifold as this will show up any leaks you may have

could the egr valve cause this? noticed the missfire doesnt go when the belts off but its slightly better. thanks lee

im going in to have anouther bash 2moz like its at work and there gay and dont let non workers in so gotta do it all on my own which is gay! cheers anyway though mate :) hopefully il get it sorted tomorrow! :)

when i did my head gasskit i 4got to do up the inlet bolts tite and ther was a slight air leak and that made it run lyk a bag of shit and rev up and dwn on its own and the eml light was on give me a ring 1day this nxt week and il come help ya sort it out lee!!

today iv spent 5 pissing hours on this engine! :mad: iv changed the idle control valve the air intake sensor coolant temp sensor cam shaft sensor crank sensor took the inlet manifold off and checked throttle body e.t.c is properly seald and now it seems to run fine but with the eml light on i think this is maybe because of a slight air leak? as it every now anmd then revs up a little on its own but apart from that seems to run spot on but when the alternator belt is on it struggles to start and runs like crap iv never seen anything like this before has anyone else experienced it? its only the aircon and alternator that are electricaly supllied so what could be wrong? i did change the alternator before fitting the engine maybe the wires in wrong place? any help be much appreciated as pv isnt far way at all!! thanks for any help lee :)

anyone please ?

im thinking now that its the intake manifold pressure sensor or the intake air temperature sensor as these are the faults im getting my codes are the same or one number out but cant find a number the same as mine so i must have written them down wrong theres:

0105 Intake manifold pressure sensor

1530 Air flow relay

1411 Secondary air pump

any ideas ? :)

would these faults cause misfiring and poor running as dfescribed?

iv tryed that dan cheers iv done a quick paper cliptest and out of all the numbers the intake pressure sensor was one of the matches does it just pull out of the airbox piping? thanks lee

i had a very slight missfire and suddenly turned into a massive 1 yesterday so i changed the coil pack and leads and its all good again so if you have a spare coil pack try that

Thats the one on the pipe that comes out of the airbox.

which is that? as ive changed the temp sensor near the cambelt thanks lee

inlet temperature sensors are a common fault.

anyone got any help ?

still no luck! :( put a map sensor idle control valve and temp sensor in and still no better seems to be ok when held at higher revs but is very noticeable at low revs eml is on any more ideas? thanks lee

yeah tryed both of them no luck :(

have you tried the spark plugs or leads?

found out i cant do the paper clip test on my year of car the pin for it isnt there :( any ideas really need it running properly! someone must know pleaseee

no ideas please?

anyone? been told could possibly be a faulty map sensor? going to do the paper clip next i think :)

hi all iv just fitted a 1.4 16 valve sport engine x14xe in to my sport its got power steering and air con due to the old one dropping a valve got it started first time but it has a slight missfire more noticeable at idle then when you rev it its there but doesnt really str#uggle to rev but you can tell its there if you knwo what i mean? anyway the eml light is on, the car doesnt have the alt belt on could this put the light on? or hav i missed a connector or earth possibly? iv put plugs and coil pack out of my other corsa that runs fine and it didnt really change it so any help would be great! thanks lee :)